Hyundai Ioniq: Engine Control/Fuel System / Fuel Delivery System
Hyundai Ioniq (AE) 2017-2025 Service Manual / Engine Control/Fuel System / Fuel Delivery System
- Components and components location
- Fuel pressure test
- Release residual pressure in fuel line
- Fuel Tank. Repair procedures
- Fuel Pump. Repair procedures
- Fuel Filter. Repair procedures
- Fuel Pump Motor. Repair procedures
- Fuel Sender. Repair procedures
- Fuel Pressure Regulator. Repair procedures
- Fuel Line. Repair procedures
- Filler-Neck Assembly. Repair procedures
- Accelerator Pedal. Repair procedures
- Fuel Pump Control Module (FPCM). Description and operation
- Fuel Pump Control Module (FPCM). Schematic diagrams
- Fuel Pump Control Module (FPCM). Repair procedures
- Fuel Pressure Sensor (FPS). Description and operation
- Fuel Pressure Sensor (FPS). Specifications
- Fuel Pressure Sensor (FPS). Schematic diagrams
- Fuel Pressure Sensor (FPS). Repair procedures
- Delivery Pipe. Repair procedures
- High Pressure Fuel Pump. Repair procedures
Repair procedures
Inspection[Motor]1.Turn the ignition switch OFF.2.Disconnect the EEGR valve connector.3.Check that the EEGR valve is stuck by foreign material. 4.Measure resistance between motor 1 and 3 control terminals of the motor...
Components and components location
Components Location[Fuel Tank]1. Fuel tank2. Fuel pump3. Fuel filter4. Fuel pressure regulator5. Canister6. Fuel tank air Filter7. Fuel pressure sensor (FPS)8...
Other information:
Hyundai Ioniq (AE) 2017-2025 Owner's Manual: High Mounted Stop Lamp Replacement
1. Open the liftgate. 2. Gently remove the cover of the liftgate trim. 3. Remove the spoiler plug hole. 4. Disconnect the electrical connector. 5. Loosen the mounting bolts and remove the spoiler. 6. Remove the high mounted stop light assembly after disconnecting the connector...
Hyundai Ioniq (AE) 2017-2025 Service Manual: Inspection
Inspection[Battery Pack Assembly Troubleshooting Chart] • For SOC check, refer to "SOC Inspection"• For voltage check, refer to "Battery Voltage Inspection"• For battery voltage sensing circuit, refer to "Voltage Sensing Circuit Inspection"• For isolation resistance check, refer to "Isolation Resistance Inspection" [SOC Level and Follow-up] SOC Symptom Warning Lamp Follow-up MIL Service Fuel • Normal --- 10 - 15% • Motor torque limite (Acceleration delay)--ON• Refuel and check the SOC againON--• Repair the MIL or Service Lamp related system• Charge the battery by starting the engine• Refuel if necessary ONON--ON-OnONON 5 - 10% • EV Mode inhibited • FATC Inhibited • LDC Inhibited --ON• Refuel and check the SOC againON--• Repair the MIL or Service Lamp related system• Charge the battery by starting the engine • Refuel if necessaryONON--ON-ONONON 0 - 5% • Impossible to start ON--• Repair the MIL or Service Lamp related system• Start the engine with GDS to charge the battery• Refuel if necessary ONON--ON-ONONON 0% ON--• Repair the MIL or Service Lamp related system• If necessary, Replace Battery Pack• Refuel if necessary [SOC Inspection]1...
Categories
- Manuals Home
- 1st Generation Ioniq Owners Manual
- 1st Generation Ioniq Service Manual
- High Beam Assist (HBA)
- Check Hybrid system, Check Hybrid system. Turn engine Off
- Check brakes/Check regenerative brakes, Check Virtual Engine Sound System
- New on site
- Most important about car
Rear Seats
Folding the rear seat
The rear seatbacks can be folded to facilitate carrying long items or to increase the luggage capacity of the vehicle.
WARNING
Never allow passengers to sit on top of the folded down seatback while the vehicle is moving. This is not a proper seating position and no seat belts are available for use. This could result in serious injury or death in case of an accident or sudden stop. Objects carried on the folded down seatback should not extend higher than the top of the front seatbacks. This could allow cargo to slide forward and cause injury or damage during sudden stops.
Copyright © 2025 www.hioniqae.com